基于通嘉LD5523E2 QR+CCM 24W PSR的适配器电源解决方案
原标题:基于通嘉LD5523E2 QR+CCM 24W PSR 的适配器电源方案
消费型适配器市场应用上,目前主要使用 SSR 架构应用在小于 45W 的适配器产品, PSR 架构大部分使用于小于18W功率的产品,通嘉新一代的 Flyback 产品导入PSR 架构于 LD5523E2,可有效减少原本 SSR 架构 BOM 上的组件数量,产品适用性也拉大到 45W 的应用,在小于 45W 适配器的成本上有更大的优势。且LD5523E2 有优秀的混模技术QR+CCM,效率表现等同SSR;具有线补,可降低输出DC 线号;低频升压机制,降低ripple,减少输出入电容值;低待机功耗;频率切换范围加大,较佳的EMI 表现;支持BNI/BNO 功能;逻辑保护齐全,可靠性高。
场景应用图
展示板照片
方案方块图
核心技术优势
1. SOT-26 6pin 封装小,PSR回授,支持多重操作模式
2. 支持high/low line 75KHz/65KHz 操作频率
3. 支持 Brown in/out 功能
4. OVP/OLP/CSOVP/SDSP/OTP 保护设计齐全
5. 新频率切换技术,较佳的 EMI 表现
方案规格
1. 适用 18 ~ 45W 输出功率
2. Flyback PSR 架构
3. QR + CCM 混模
4. 超低起动电流 < 1.5uA
5. 与 SSR 可共享 PCB 设计
技术文档
类别 | 标题 | 档案 |
---|---|---|
硬件 | Power test report | |
硬件 | Schematics+BOM |
【LD5523E2】
PWM+QR Multi-mode Controller with Primary Side Regulation
In order to enhance the efficiency performance, the LD5523E2/K2/A2 integrates the multi-mode PWM controller, which consists of Quasi-Resonant (QR) PWM control for light load condition and Continue Conduction Mode (CCM) for heavy load condition. Moreover, the QR controller gains the system performance, but also brings the worse EMI capability, especially at boundary mode in heavy load. While the frequency swapping function of LD5523E2/K2/A2 can reduce the EMI emission of SMPS and helps the power circuit designers to simply deal with EMI filter and saves several component and developing time.
The LD5523E2/K2/A2 is implemented in SOT-26 package, and includes the comprehensive protection function, such as Over Load Protection (OLP), Over Voltage Protection (OVP), Output Short Circuit Protection (OSCP) and adjustable Over Temperature Protection (OTP). Furthermore, the programmable brown-in/out protection is built-in.
Features
PSR CCM+QR Multi-Mode Control.
Frequency Swapping for better EMI performance
Low Startup Current (<1.5mA)
Built-in load regulation compensation
65 kHz PWM switching frequency.
Current mode control with cycle-by-cycle current limit
UVLO (Under Voltage Lock Out)
LEB (Leading-Edge Blanking) on CS pin
VCC & FB Over Voltage Protection
Bulk Over Voltage Protection (K2 only)
Adjustable Brown in/out on FB pin.
External OTP (Over Temperature Protection) on CS Pin
Internal OTP (Over Temperature Protection)
Gate Source/Sink Capability: 40mA/-170mA @ output pin with 1nF capacitor.
Application
Networking power supply
Lower Power AC/DC Adaptor
责任编辑:David
【免责声明】
1、本文内容、数据、图表等来源于网络引用或其他公开资料,版权归属原作者、原发表出处。若版权所有方对本文的引用持有异议,请联系拍明芯城(marketing@iczoom.com),本方将及时处理。
2、本文的引用仅供读者交流学习使用,不涉及商业目的。
3、本文内容仅代表作者观点,拍明芯城不对内容的准确性、可靠性或完整性提供明示或暗示的保证。读者阅读本文后做出的决定或行为,是基于自主意愿和独立判断做出的,请读者明确相关结果。
4、如需转载本方拥有版权的文章,请联系拍明芯城(marketing@iczoom.com)注明“转载原因”。未经允许私自转载拍明芯城将保留追究其法律责任的权利。
拍明芯城拥有对此声明的最终解释权。